Chevrolet Malibu (2006) – fuse box diagram
Year of production: 2006
Body Control Module (BCM)
The instrument panel fuse block is located at on the lower front side of the console, on the passenger side of the vehicle.
| Device | Ampere rating [A] | Usage |
| AIRBAG (BATT) | 10 | Infiatable Restraint Sensing and Diagnostic Module (SDM) |
| AIRBAG (IGN) | 10 | Infiatable Restraint Sensing and Diagnostic Module (SDM) |
| CLUSTER/THEFT | 10 | Instrument Panel Cluster (IPC), Theft Deterrent Control Module |
| DOOR LOCK | 15 | Body Control Module (BCM) Logic |
| EPS | 2 | Power Steerinf Control Module |
| HVAC BLOWER | 20 | HVAC Control Module (C60) |
| HVAC BLOWER HIGH Relay | — | Blower Motor (C60) |
| HVAC CTRL (BATT) | 10 | Data Linc Connector (DLC) and HVAC Control Module |
| HVAC CTRL (IGN) | 10 | HVAC Control Module |
| IGN SENSOR | 2 | Ignition Switch |
| INTERIOR LIGHTS | 10 | Body Control Module (BCM) Logic |
| ONSTAR | 10 | Vehicle Communication Interface Module (VCIM)(UE1) |
| PEDAL | 10 | Adjustable Pedals Module (JF4) and Adjustable Pedals Posiution Switch (JF4) |
| POWER MIRRORS | 2 | Outside Rearview Mirror Switch |
| POWER WINDOWS | 30 | Window Switch – Driver and Window Switch – Passenger |
| RADIO | 10 | Radio |
| ROOF/HEAT SEAT | 20 | Heated Seats Control Module – Driver (KA1), Heated Seat Control Module – Passenger (KA1), Heated Seat Switch – Driver (KA1), Heated Seat Switch – Passenger (KA1), Inside Rearview Mirror (DD8), and Sunroof Control Module (CF5) |
| RUN/CRANK | 2 | A/T Shift Lock Control Assembly, Cruise Control On/Off Switch |
| WIPER SW | 10 | Windshield Wiper/Washer Switch |
Engine Compartment Fuse Block
The engine compartment fuse block is located on the driver’s side of the vehicle, near the battery.
| Fuses | Device | Ampere rating [A] | Usage |
| 1 | A/C CLU | 10 | A/C CLUTCH Relay 34 |
| 2 | ETC | 15 | Powertrain Control Module (PCM)(L61), Electronic Throttle Control (LX9) |
| 3 | IGN1 | 15 | Ignition Control Module (ICM), Park Neutral Position Switch |
| 4 | TRANS | 10 | 1-2 Shift Solenoid (1 – 2 SB) Valve, 2 – 3 Shift Solenoid (2 – 3 SS) Valve, Torque Convertor Clutch Pulse Width Modulation (TCC PWM) Soleniod Valve |
| 5 | INJ | 10 | Fuel Injectors |
| 6 | EMISSION 1 | 10 | Evaportive Emission (EVAP) Canister Purge Solenoid, Heated Oxygen (HO2S) Sensors, Mass Air Flow (MAF)/Intake Air Temperature (IAT) Sensor |
| 7 | LH LOW | 10 | Headlamp Low Beam – Left |
| 8 | HORN | 15 | Horn Relay 37 |
| 9 | RH LOW | 10 | Headlamp Low Beam – Right |
| 10 | FRT FOG LP | 10 | FRT FOG LP Relay 36 (T96) |
| 11 | LH HIGH | 10 | Headlamp – High Beam – Left |
| 12 | RH HIGH | 10 | Headlamp – High Beam – Right |
| 13 | PCM | 10 | Powertrain Control Module (PCM) |
| 14 | WIPER Fuse | 25 | Wiper 1 Relay 39 |
| 15 | ABS | 10 | Electronic Brake Control Module (EBCM)(JL9/JM4) |
| 16 | PCM IGN 1 | 10 | Powertrain Control Module (PCM) |
| 17 | C/FAN 1 | 30 | Cooling Fan 1 Relay 28 |
| 18 | C/FAN 2 | 30 | Cooling Fan 2 Relay 30 |
| 19 | RUN RLY | 30 | Blower Motor Control Module (C68), HVAC BLOWER HIGH Relay (C60), RUN Relay |
| 20 | IBCM 1 | 30 | Body Control Module (BCM), AIRBAG (BATT) Fuse, CLUSTER/THEFT Fuse, HVAC CTRL (BATT) Fuse, IGN SENSOR Fuse, and RADIO Fuse |
| 21 | IBCM (R/C) | 30 | AIR BAG (IGN) Fuse, EPS Fuse and RUN/CRANK Fuse |
| 22 | RBEC 1 | 60 | AUX PWR #2 Fuse 12, BACK UP LP Fuse 17, CIG/AUX Fuse 20 HTD ST FUSE 14, RKE/XM/DVD/UGD Fuse 16, SUN RF Fuse 10 and RR DEFOG Relay 26 |
| 23 | RBEC 2 | 60 | DRV ST Fuse 2, EMISSION 2 Fuses 5, FUEL Fuse 25, PARK LPS Fuses 6, and TRUNK Fuse 22 |
| 24 | ABS | 60 | Electronic Brake Control Module (EBCM)(JL9) |
| 25 | IBCM 2 | 50 | DOOR LOCK Fuse, INTERIOR LIGHT Fuse and ACCESSORY Relay |
| 26 | STARTER | 30 | Starter Relay 31 |
| 27 | WIPER Diode | — | Wiper 1 Relay 39, Wiper 2 Relay 40 |
| 28 | COOL FAN 1 Relay | — | Cooling Fan – Left |
| 29 | COOL SER/PAR Relay | — | Cooling Fan – Left, Cooling Fan – Right |
| 30 | COOL FAN 2 Relay | — | Cooling Fan – Right |
| 31 | STARTER Relay | — | Starter Solenoid |
| 32 | RUN/CRANK Relay | — | ABS Fuse 15, IBCM (R/C) Fuse 21, IGN 1 Fuse 3, INJ Fuse 5, PCM IGN 1 Fuse 16, TRANS Fuse 4 |
| 33 | POWERTRAIN Relay | — | Emission 1 Fuse 6, and ETC Fuse 2 |
| 34 | A/C CLUTCH Relay | — | A/C Compressor Clutch |
| 35 | HIGH BEAM Relay | — | LH High Fuse 11, RH HIGH Fuse 12 |
| 36 | FRT FOG Relay | — | Fog Lamp – LF (T96), Fog Lamo RF (T96) |
| 37 | HORN Relay | — | Horn Assembly |
| 38 | LOW BEAM Relay | — | LH LOW Fuse 7, RH LOW Fuse 9 |
| 39 | WIPER 1 Relay | — | Wiper 2 Relay 40 |
| 40 | WIPER 2 Relay | — | Windshield Wiper Motor Assembly |
| 41 | EPS | 80 | Power Steering Control Module |
| 42 | BRAKE LAMP DIAGNOSTIC Resistor | 620 ohm | Body Control Module |
| 43 | Relay | Ignition Module | |
| 44 | Relay | Fuel Injectors | |
| 45 | Relay | Intake Tuning Valve | |
| 46 (Resistor) | Relay | Brake Lamp Diagnostic | |
| 47 | Relay | Daytime Running Lamps | |
| 48 | Relay | Daytime Running Lamps |
Rear Compartment Fuse Block
The rear compartment fuse block is located in the trunk of the vehicle. Access the fuse block through the trunk panel on the driver’s side of the rear cargo area.
| Fuses | Device | Ampere rating [A] | Usage |
| 1 | — | — | — |
| 2 | DRV ST | 30 | Seat Adjuster Switch – Driver |
| 3 | — | — | — |
| 4 | DR DOOR KEY CYL Resistor | 620 ohm | Door Lock Actuator – Driver |
| 5 | EMISSION 2 | 10 | Evaportive Emission (EVAP) Canister Solenoid Valve |
| 6 | PARK LPS | 10 | PARK LPS Relay 27 |
| 7 | — | — | — |
| 8 | — | — | — |
| 9 | — | — | — |
| 10 | SUB RF | 15 | Sunroof Control Module (CF5) |
| 11 | — | — | — |
| 12 | AUX PWR #2 | 20 | Auxiliary Power Outlet – Rear (Extanded Sedan) |
| 13 | — | — | — |
| 14 | HTD ST | 15 | Heated Seat Control Module – Driver (KA1) and Heated Seat Control Module – Passenger (KA1) |
| 15 | — | — | — |
| 16 | RKE/XM/DVD/UGD | 7,5 | Digital Radio Reciver (U2K), DVD Player (U32), Garage Door Opener Transmitter (UG1), and Remote Control Door Lock Reciver (RCDLR) |
| 17 | BACK UP LP | — | BACK UP LP Relay 33 |
| 18 | — | — | — |
| 19 | — | — | — |
| 20 | CIG/AUX | 20 | Auxiliary Power Outlet – console (NW7, NW9), Auxiliary Power Outlet – Front (w/o NW7, Nw9) and Cigar Lighter |
| 21 | — | — | — |
| 22 | TRUNK | 10 | TRUNK Relay 36 |
| 23 | RR DEFOG | 30 | Rear Window Defogger Grid |
| 24 | HTD MIR | 10 | Outside Rearview Mirror – Driver (DL8), Outside Rearview Mirror – Passenger (DL8) |
| 25 | FUEL | 15 | FUEL Relay 37 |
| Relays | Device | Usage |
| 26 | RR DEFOG Relay | RR DEFOG Fuse 23 and HTD MIR Fuse 24 |
| 27 | PARK LPS Relay | Backup Lamp – Left, Backup Lamp, Right, Body Control Module (BCM), Garage Door Opener Transmitter (UG1), HVAC Control Module (C60), License Lamp (Extanded Sedan), License Lamp – Left (Sedan), License Lamp – Right (Sedan) Park/Turn Signal Lamp – LF, Park/Turn Signal Lamp – RF, Tail Lamp – Left, Tail Lamp – Right, Tail/Stop and Turn Signal Lamp – Left, Tail/Stop and Turn Signal Lamp – Right |
| 28 | — | — |
| 29 | — | — |
| 30 | — | — |
| 31 | — | — |
| 32 | — | — |
| 33 | BACK UP LP Relay | Backup Lamp – Left, Backup Lamp – Right, and Inside Rearview Mirror (DD8) |
| 34 | — | — |
| 35 | — | — |
| 36 | TRUNK Relay | Rear Compartment Lid Latch0 |
| 37 | FUEL Relay | Fuel Pump |
| 38 | CARGO LP Diode | Cargo :a,p Switch (Extanded Sedan), Rear Compartment Lid Latch (sedan) |
WARNING: Terminal and harness assignments for individual connectors will vary depending on vehicle equipment level, model, and market.